9mm-10mm-comparison
Copyright 2009 Brasstard.com

As a huge fan of the 10mm Auto cartridge, it was only natural for me to give the little beast some server space here at Adiga Armory. DoubleTap Ammo has been one of few ammo factories who load the 10mm up to it’s full potential. In this post, we will take a look at 3 of their full-power 10mm loadings to see how they hold up.

Here they are in all of their glory…

10mm-ammo-1
Copyright 2009 Brasstard.com
  1. Left) DoubleTap 10mm Auto – 200g Controlled Expansion/Hornady XTP-JHP
  2. Center) DoubleTap 10mm Auto – 165g Remington Golden Saber-JHP
  3. Right) DoubleTap 10mm Auto – 200g FMJ-FP

All 3 rounds gave me reasonably good accuracy. However, they are not designed to provide match-grade accuracy. If you want match ammo, you have to sacrifice some velocity. These loads are a bit on the warm side, and are designed to hit hard as opposed to making overlapping holes on paper at 50 yards.

Here is the test gun (my backcountry defensive weapon of choice), the venerable Glock model 20 (Gen 3). This one is fortified with a 22lb recoil spring, stainless steel guide rod, and night sights. The rest is bone-stock Glock…

G20
Copyright 2009 Brasstard.com

The test medium was water-soaked phone books, the elevation was 5400 ft, and the temp was a balmy 1 degree Celsius. The first rounds I tested were the Golden Saber and the XTP. I wanted to see what they would do to a single book at nearly point-blank range. Here are the results from firing about 5 feet away…

10mm-entry-GS-single-book
Copyright 2009 Brasstard.com

Believe it or not, the image above is actually the entry wound of the Golden Saber at extremely close range. And here is the exit shown below…

10mm-exit-GS-single-book
Copyright 2009 Brasstard.com

The exit wound looks like it was made by 2 separate projectiles… that is sort of what happened. It appears that the Golden Saber literally shattered on impact with the wet mass. There was likely a core-jacket separation which caused the two to exit at different points in the rear. The tissue damage spread to about 5″ from top to bottom… straight up nasty.

Now lets take a look at what the 200g Hornady XTP does to a single phone book inside of 5 feet…

10mm-entry-XTP-single-book
Copyright 2009 Brasstard.com

As you can see, the entry wound is significantly more conservative than the Golden Saber was. This is likely due to the fact that this bullet is much slower and heavier. It also has a much less aggressive cavity in the tip which slows expansion, hence the term “controlled expansion”. Despite the conservative entry wound, the exit wound was outrageous…

10mm-exit-XTP-single-book
Copyright 2009 Brasstard.com

The XTP damage dwarfs even the respectable Golden Saber load. The exit wound from the XTP at close range disrupted a diameter of nearly 8″ of tissue… truly awesome performance. This is what you might expect from a hot loaded .357 Magnum round out of a long-barrel revolver.

Since both loads easily passed through one book, I didn’t bother to test the FMJ-FP here. Those would have cut through like it wasn’t even there. Next, I placed 2 books back to back to see what happens. Here are the results when shooting from a more reasonable range of 7 yards…

10mm-entry-wound-book-1
Copyright 2009 Brasstard.com

The entry wounds above indicate that the Golden Saber seems to have less of a tendency to explode on impact if you give it a little bit of distance from the muzzle. At this range, they only lose around 30 fps, but I guess it must make a difference.

Here they are coming out of the back of the first book.

10mm-exit-wound-book-1
Copyright 2009 Brasstard.com

Notice the severe necrosis and shock ripples around the wound channels… this means we are beginning to see signs of hydrostatic shock. Both JHP rounds are showing significant deformation by this point. Remember, one phone book represents between 8″-10″ in ballistic gelatin. The Golden Saber has again suffered a core-jacket separation resulting in two distinct wound channels. The XTP is holding up like a champ, showing severe tissue damage… and of course the FMJ-FP is just getting warmed up by this point.

Here they are coming out the back of the second phone book…

10mm-exit-wound-book-2
Copyright 2009 Brasstard.com

Apparently, the Golden Saber’s jacket did not exit, and was found lodged in the middle of the second book. Only the bullet core made it through. The XTP on the other hand created a hole so large, that it consumed/engulfed the entire wound channel of the FMJ-FP. Though this particular bullet was not recovered, it shows signs of good structural integrity. The XTP performed how it is supposed to… giving us deep penetration and great expansion. Clearing two phone books is equal to over 16″ in ballistic gelatin.

As for the 200g FMJ-FP, it just plowed right through those two books like a pack of hyenas through a half-eaten zebra carcass. I therefore decided to place four phone books back-to-back, assuming that there was no way it would make it through all of them. Well guess what?… I was wrong. I fired two rounds through four fresh phone books at 7 yards, and both rounds fully penetrated and were not recovered. I would have then tried five books, but by this point I had run out of fresh wet phone books. This means the FMJ-FP load will clear at least 32″-40″ in ballistic gel and still keep on going.

Here are the exit wounds on the back of the fourth book…

10mm-exit-wound-book-4-FMJ
Copyright 2009 Brasstard.com

The one on the left appears to have tumbled a bit, creating a longer wound channel and knocking the last phone book down as it passed through. These bullets make a great load for the woods where deep penetration is the key to a quick stop with a pistol.

I then decided to fire some JHP’s at the four book’s to see how deep they go, and to recover some expanded bullets. Here are the results…

10mm-XTP-expaded-bullets
Copyright 2009 Brasstard.com

The XTP held together nicely, retaining an average of 197.33 grains and expanding to an average diameter of 17.61 mm (0.69″)… more than a 70% diameter increase! All rounds were discovered in the beginning of the third book, equating 18″+ of penetration in gelatin. These would make perfect hunting rounds for deer and wild hogs.

10mm-GS-expaded-bullets
Copyright 2009 Brasstard.com

Unfortunately, the Golden Saber did not fare so well. Every single recovered bullet had shed its jacket. I have had great results with the Golden Saber bullet design in lower-velocity calibers like 9mm/38+p/40SW/45ACP. However, it consistently failed to hold together in this platform. The average recovered bullet weight was only 126 grains, and the average recovered diameter was 21.27 mm (0.83″) for the jacket and a mere 13.45 mm (0.53″) for the core. The jackets were discovered in the rear half of the second book, and the cores were discovered in the first quarter of the third book. This equates to 14″-18″+ of penetration in calibrated ordinance gelatin.

Despite the core-jacket separations, the Golden Saber load makes a nasty wound channel and doesn’t excessively penetrate. Keep in mind that wet paper is more dense than human body mass, and may be harder on bullets as a result. Therefore, I wouldn’t discredit it as a viable defensive load against 2-legged predators. Just don’t expect it to work miracles through something like an automobile windshield. Perhaps DoubleTap might consider using the newer, bonded Golden Sabers for this load in the future.

Chronograph Velocity Results

5-shot Average @ 10 Feet Glock G20 4.6″ Barrel

  1. Golden Saber 165g – 1307 fps / 626 fpe
  2. XTP 200g – 1112 fps / 549 fpe
  3. FMJ-FP 200g – 1101 fps / 538 fpe

As you can see, these loads did not achieve the firm’s advertised velocities… one would expect about 1140 fps from a 4.6″ barrel. It is not uncommon in the 10mm world for boutique ammo makers to be a little over-blown with their claimed performance… its not just DoubleTap that does it. Despite this, they still performed nicely against the wet mass. And realistically, you can’t expect a lot more in a 4.6″ barrel without going over-pressure. 

Is it just an over-priced .40 S&W?

Some folks claim that the 10mm Auto is just an overpriced version of its offspring, the .40 S&W. I guess if you look at modern factory ammo from the big names, they may be right in making this claim. After all, much of the 10mm big box factory ammo is loaded down to virtual .40 levels; with 200g loads running at around ~1000 fps. Needless to say, this is not “real” 10mm Auto folks. It is watered-down, liability-resistant, .40 S&W loaded into a 10mm Auto case, and stamped with a bloated price tag. The “real” loads, the ones that are closer to original Norma specs, are elevated to a much higher performance class.

This is a similar test using a Glock model 23, and firing a .40 S&W 155g bonded Winchester Ranger JHP… a round considered by many to be one of the better factory loads on the market. The exit wound was 3″ end-to-end…

40SW-entry-ranger-single-book
Copyright 2009 Brasstard.com
40SW-exit-ranger-single-book
Copyright 2009 Brasstard.com

Nothing against the .40… its a great all-around defensive cartridge, and a well-balanced compromise between power and shoot-ability. But as you can see, it is not quite the same beast.

The diagnosis: 10mm Auto kicks some serious butt when using full-power loads. Plus, a simple barrel swap allows you to fire cheaper .40 S&W out of your Glock. So I ask the nay-sayers, whats not to like?

Be safe out there, and happy shooting.

Adiga Armory

In Review: 10mm Auto From DoubleTap
Tagged on:                 

11 thoughts on “In Review: 10mm Auto From DoubleTap

  • April 25, 2014 at 13:37
    Permalink

    I cannot find DoubleTap 10mm Auto – 200g Controlled Expansion/Hornady XTP-JHP anywhere including double taps website. Could you show me a link to where i can find some i would love to get it and carry it in my g29 for woods use.

    Reply
    • June 20, 2014 at 10:30
      Permalink

      Reply from Admin,
      Sounds like it’s time to load your own… 200g XTP over Accurate #9 does the trick.

      Reply
  • October 7, 2013 at 13:38
    Permalink

    Just had to make a quick observation about the fact that Golden Saber rounds were used in this test with a stock Glock barrel. This is actually a problem because of the rifling of the stock Glock barrel. It’s not the type of rifling that’s the problem but rather the fact that stock Glock barrels use a right-hand twist. If you look at the Golden Saber round you’ll notice that it’s not “notched” in a straight up and down pattern like other standard JHP’s, instead their notches are directional and in a left-hand twist pattern.

    I would love to see this comparison done again but this time using a Lone Wolf barrel (left-hand twist). I can almost guarantee you’ll see a vast improvement in the performance of the Golden Saber while the others will obviously remain the same. I’ve seen this test done with ballistics gelatin and the difference is night and day. Through a LHT barrel the GS round is BRUTAL!

    Reply
  • May 11, 2012 at 05:20
    Permalink

    Hornady markets different bullets for different tasks. Soft bodied targets (ccw targets) are better served with “Critical Defense” rounds. Targets that need to be served through more aggressive intermediate barriers are better worked by “Critical Duty” rounds. The Golden Saber rounds are no different. If you CC and most likely won’t need to penetrate aggressive barriers, then Golden Saber rounds do offer quite an adequate nasty “buckshotish” effect without the fear of undue overpenetration. The 10mm is sexy! and hot. Golden Saber rounds demenish some of the liability in shooting the people behind your bad guy while dropping his butt. Not advised for anything four legged!

    Reply
  • April 24, 2012 at 14:43
    Permalink

    UnderWood Ammo as of present is a real go to on true 10mm loads.Priced right and variety.Speak to a Kevin,great guy.Very good source.The problems of getting real 10mm are not a problem.

    Reply
  • February 16, 2012 at 14:27
    Permalink

    Are you kidding me, the Golden Sabre is exactly what you want for personal defense “combat”. It penetrates, leaves an enourmous would channel and gives two distinct exit wounds, or internal wound tracts. Point is, they are designed to kill and they will do that perfectly.

    Reply from Admin;
    I do agree that the GS bullet is a great design. Heck, factory Remington GS has been my chosen 9mm carry load for years now. However, this DT load far exceeds the original bullet and cartridge design parameters for the Golden Saber. The GS bullet was optimized for velocities between 850-1150 fps, not 1400+. While it may sound cool to read about bullets coming apart on the internet, real world core/jacket separation is no joke. They call it “bullet failure” for a reason; because it severely diminishes the potency of the projectile. If the GS load from DT comes apart every single time through some mushy phone books, imagine what will happen if it encounters a hard barrier such as sheet metal, auto glass, etc… I seriously doubt it would remain in tact. Actually, the example above is less matter of bullet failure than it is a matter of cartridge design failure. Based on the evidence above, DoubleTap Ammo needs to chose a different bullet for this load… perhaps the Golden Saber “Bonded”.

    Reply
  • September 27, 2010 at 11:01
    Permalink

    Robert,
    I had the opportunity to chrono some 175g Silvertip’s out of my G20 last week. They produced an average velocity of 1218 fps, which is about 576 ft/lb of energy at the muzzle. That is one of my favorite big-factory loads. If I come across any 180g D.T. Gold Dot loads, I’ll be sure to post the results.

    Reply
  • September 17, 2010 at 08:42
    Permalink

    I agree. I compare the 10mm Auto to full power .357 Magnum in an auto. And Mike McNett makes awesome ammunition. His 180 Gold Dot load has become my Go-To load in my Glock 20. I would like to see it tested next to the old standby Winchester 175 gr Silvertips.

    No other auto cartridge on the planet comes close to the utility and versatility of the 10mm Auto. None of the more mainstream cartridges would have made it nearly as long based strictly on their performance rather than big name endorsements and advertising, or military careers. The 10mm Auto is alive and well decades after most thought it was dead. All hail the 10mm Auto!

    Reply
  • January 16, 2010 at 06:06
    Permalink

    The 10mm is very good.

    Reply

Leave a Reply to Glock 20 Cancel reply

Your email address will not be published. Required fields are marked *